Product ID:3335WZ AQUA LYTE GLOSS BLACK
MSDS Date:06/13/1995
FSC:8010
NIIN:00F048558
MSDS Number: BZFPW

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ ST
CARSON, CA 90749-5000
US

Emergency Phone: 213-513-0700

Info Phone: 213-513-0700

Preparer: JOHN R KORDOSH

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

DIMETHYL ETHER, METHYL ETHER

CAS: 115-10-6

RTECS: PM4780000

Fraction By Weight: 40%

ACGIH TLV: NONE

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)

CAS: 107-98-2

RTECS: UB7700000

Fraction By Weight: 5-10%

ACGIH TLV: 100 PPM

2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 2%

OSHA PEL 50 PPM (SKIN)

ACGIH TLV: 25 PPM (SKIN)

SEC-BUTANOL ALCOHOL

CAS: 78-92-2

RTECS: EO1750000

Fraction By Weight: 2%

OSHA PEL 150 PPM

ACGIH TLV: 303 MG/CUM

ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE, BUTYL CELLOSOLVE

CAS: 112-07-2

RTECS: KJ8925000

OSHA PEL 50 PPM

ACGIH TLV: 25 PPM

PROPASOL P; GLYCOL ETHER P; 1-PROPOXY-2-PROPANOL

CAS: 1569-01-3

RTECS: UB9351000

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITANT.
NERVOUS SYSTEM DEPRESSION. EYES: IRRITATION/BURNING. SKIN:
IRRITATION/DERMATITIS/ABSORPTION. INGESTION: GI DISTRESS. PETROLEUM
DISTILLATES MAY CAUSE LUNG INFLAMMATI ON, DAMAGE/EVEN DEATH.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENT MAY CAUSE PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
STAGGERING GAIT, LASSITUDE, LOSS OF COORDINATION, CONFUSION,
UNCONSCIOUSNESS, BURNING, DISCOMFORT, EYE WATERING, DRYNESS/REDNESS
OF SKIN, DEFATTING, DISTRESS, VOMITING, INFLAMMATION
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
RESPIRATORY DISORDERS

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR, PREFERABLY
MOUTH-TO-MOUTH. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15
MINS. SKIN: WASH W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING,
KEEP HEAD LOWE R THAN WAIST. ASPIRATION OF VOMITUS MAYRESULT IN
CHEMICAL PNEUMONITIS/PULMONARY EDEMA. OBTAIN MEDICAL ATTENTION IN
ALL CASES.

Flash Point Method:TOC
Flash Point:-42F
Lower Limits:0.88
Upper Limits:18
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:AVOID CONFINED SPACES. WEAR FULL PROTECTIVE
EQUIPMENT W/A POSITIVE PRESSURE NIOSH APPROVED SCBA. WATER MAY BE
UNSUITABLE AS AN EXTINGUISHING MEDIUM. (SEE SUPP)
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY ACCUMULATE IN LOW
AREAS OF POOR VENTILATION/TRAVEL ALONG THE GROUND TO REMOTE
IGNITION SITES. (SEE SUPP)

Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES,
INCLUDING HOT METAL SURFACES. WEAR CLOTHING & GEAR. PREVENT SKIN
CONTACT & AVOID BREATHING OF VAPOR. CONFINE IMMEDIATELY & REMOVE
W/INERT ABSORBENT SUCH AS CLA Y/SAND.

Handling and Storage Precautions:KEEP FROM SUNLIGHT/IGNITION SOURCES.
CAP CONTAINER AFTER EACH USE. DON'T STORE >120F. STORE IN A DRY,
WELL VENTILATED AREA. OBSERVE LABEL PRECAUTIONS.
Other Precautions:DON'T SPRAY NEAR FIRE/FLAME. AVOID CONTACT. DON'T
TAKE INTERNALLY. DON'T PUNCTURE CONTAINERS. USE W/ADEQUATE
VENTILATION. DON'T INHALE VAPORS. DON'T SAND/FLAME CUT/BRAZE/WELD
DRY COATING W/O A NIOSH/M SHA RESPIRATOR/SUFFICIENT VENTILATION.

Respiratory Protection:IF TLV/PEL ARE EXCEEDED, WEAR A PROPERLY FITTED
VAPOR & PARTICULATE/POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR
APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING APPLICATION & UNTIL
ALL VAPORS & SPRAY MIST S ARE EXHAUSTED.
Ventilation:SUFFICIENT VENTILATION TO KEEP CONTAMINANTS OSHA REQUIREMENTS. USE EXPLOSION-PROOF EQUIPMENT.
Protective Gloves:NEOPRENE
Eye Protection:GOGGLES, SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:FACESHIELD, PROTECTIVE CREAMS, APRON,
COVERALLS, WORK CLOTHES, EYE WASHES, SAFETY SHOWERS
Supplemental Safety and Health

HCC:V3
Boiling Pt:B.P. Text:-13F-367F
Vapor Density:>1
Spec Gravity:0.8
VOC Grams/Liter:5.03
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS & BASES, SELECTED AMINES
Stability Condition to Avoid:HEAT, SUNLIGHT, SPARKS, OPEN FLAME/FIRE &
OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, UNIDENTIFIED ORGANIC
COMPOUNDS

Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. PLACE IN NON-LEAKING CONTAINERS. DISPOSE OF IAW/LOCAL,
STATE & FEDERAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.